Pneuline Controls Air Station Accessories
Oil Coalescing Air Filters
Use to remove aerosols, solid contaminants and oil vapors from compressed air systems using lubricated compressors. Coalescing filters offer a much higher degree of oil removal efficiency than standard air filters.
The automatic drain works on pressure of 20-175 PSIG and has 1/8" NPT drain port. This filter removes 99.97% of all aerosols—unmatched by any other method.
Standard or “Pre Filter” Air Filters
With new mini-style thermostats and smaller orifices used in pneumatic control, it is essential that you deliver very clean air. Contaminants can cause more trouble with new equipment than ever before. The Pneuline 5-Micron Reusable Pre Filter traps dirt and aerosols in its 11 ounce bowl. For Automatic Drain, add “-AD” to end of model number (example: SAF114M-AD)
“EL Cheapo” Filters!
For continuing contamination problems, this filter is a very inexpensive solution. The refill is very readily available in any janitor’s closet—a roll of toilet paper!
Size: 1/4” NPT
Handy for emergency use when there is a failure in your air station filtration system. Element included.
Intake Filter Replacement Kits
Where clean air begins—every compressor intake air filter should be inspected regularly and replaced promptly when needed. The Pneuline replacement kit is about the same cost as the factory element only. Once the replacement kit is in place, replacement cost is minimal.
DON’T FORGET! Replace your compressed air filters regularly! Most control problems start with dirty air…
Automatic Electronic Condensate Drain Valve
The ADV automatic electronic drain valve provides a cost effective means of removing condensate from compressors, receivers, dryers and any area where condensate collects.
• NEMA 4 rating
• LED power indicator
• Adjustable time on from 0.5 to 10 seconds
• Adjustable time off from 0.5 to 45 minutes
• Manual override
• LED valve open indicator
• 6'' power cord with 120Vac plug
Flow: 1.38 gallons per 5-second discharge (based on a 90 psi compressed air system)
Max. Pressure: 300 psi
Automatic Electric Condensate Drain
The DVA Automatic Drain Valve drains condensate from after coolers, air receivers, separators, filters or any area where condensate collects.
- Solid state timer, on: 0-10 sec. off; 0-60 min.
- 3 position power switch provides either “Automatic” or “Manual” (test) operation and “OFF”.
Connection: 1/4" Includes:
Flow: 4 GPH Max Press: 200 psi
Max Press: 200 psi
Compressor Condensate Drain
Use to automatically drain condensed moisture from compressors. Nominal working pressure rating from 30 to 150 psi.
Connection: 3/8" FPT
Air Dryer Condensate Drain
Used to automatically drain condensed moisture from refrigerated air dryers.
Connection: 3/8" FPT
Flow: 10 GPH
Max Press: 100 psi
Disposable Inline Filters
With the new mini stats and their tiny orifices, the cleanliness of existing branch lines are seriously in doubt. To be sure whenever you make any modifications, install an inline filter to protect the devices from clogging prematurely.
• 1/4” barb connection
• 56 SCFH @ 25 psi max.
Miniature Pressure Regulators
- Compact and easy to use
- For testing, emergencies, or branch backup
- 1/8” gauge ports both front and back
NOTE: Please order gauges separately. See our GAUGE section for ordering information.
Precision Pressure Regulators
For Precise, Accurate Control
- 0.1 psi control
- Good calibration tool
- Fine-tune signals
• 1/4” FPT connection See our GAUGE section for ordering information.
• 0-60 psi range
NOTE: Please order gauges separately.
Standard Pressure Regulators
- For main air pressure
- Secondary air for day/night, summer/winter, or occupied/unoccupie
- 1/4” gauge ports front and back
* 5-125 psi range
Miniature Pop Safety Valves
A pressure regulator failure can blow out all the controls in your system. Install pressure relief valves in your mains for protection. Non-adjustable—factory set at 30 psi. ASME rated.
* Rating based on full release of tank pressure at 75#.
Tank Relief Valves
- Get maximum safety for compressor tank over-pressure
- Adjustable 5-300 psi relief setting
The rugged 69H pressure switch is designed for the demanding requirements of larger, heavy duty commercial air compressors.
Range: 10–125 psi
Connection: 3/8" FPT
The alternator relay provides a means of automatically alternating the operation of two separately mounted motor driven pumps or compressors. Each time a pressure increase is required by the system, the alternating action assures even readiness and wear on both pumps.
This petroleum based oil is one of the world’s finest compressor lubricants, recommended for reciprocating compressors. It offers excellent protection against wear, rust, and corrosion. It is also very stable at high temperatures.
- Extended valve life
- Better heat transfer
- Low evaporation losses
- 30 Weight